Magnesium chloride

Magnesium chloride
Names
	Other names Magnesium dichloride
Identifiers
CAS Number	7786-30-3 ; 7791-18-6 (hexahydrate) ;
3D model (JSmol)	Interactive image;
ChEBI	CHEBI:6636 ;
ChEMBL	ChEMBL1200547 ;
ChemSpider	22987 ;
ECHA InfoCard	100.029.176
E number	E511 (acidity regulators, ...)
Gmelin Reference	9305
PubChem CID	24584;
RTECS number	OM2975000;
UNII	59XN63C8VM ; 02F3473H9O (hexahydrate) ;
CompTox Dashboard (EPA)	DTXSID5034690 ;
	InChI InChI=1S/2ClH.Mg/h21H;/q;;+2/p-2 Key: TWRXJAOTZQYOKJ-UHFFFAOYSA-L ; InChI=1S/2ClH.Mg/h21H;/q;;+2/p-2;
	SMILES [Mg+2].[Cl-].[Cl-];
Properties
Chemical formula	MgCl2
Molar mass	95.211 g/mol (anhydrous); 203.31 g/mol (hexahydrate)
Appearance	white or colourless crystalline solid
Density	2.32 g/cm3 (anhydrous) ; 1.569 g/cm3 (hexahydrate)
Melting point	714 °C (1,317 °F; 987 K) 117 °C (243 °F; 390 K) (hexahydrate) ; on rapid heating: slow heating leads to decomposition from 300 °C (572 °F; 573 K)
Boiling point	1,412 °C (2,574 °F; 1,685 K)
Solubility in water	anhydrous ; 52.9 g/100 mL (0 °C) ; 54.3 g/100 mL (20 °C) ; 72.6 g/100 mL (100 °C) hexahydrate ; 235 g/100 mL (20 °C)
Solubility	slightly soluble in acetone, pyridine
Solubility in ethanol	7.4 g/100 mL (30 °C)
Magnetic susceptibility (χ)	−47.4·10−6 cm3/mol
Refractive index (nD)	1.675 (anhydrous) ; 1.569 (hexahydrate)
Structure
Crystal structure	CdCl2
Coordination geometry	(octahedral, 6-coordinate)
Thermochemistry
Heat capacity (C)	71.09 J/(mol K)
Std molar; entropy (So298)	89.88 J/(mol K)
Std enthalpy of; formation (ΔfH⦵298)	−641.1 kJ/mol
Gibbs free energy (ΔfG˚)	−591.6 kJ/mol
Pharmacology
ATC code	A12CC01 (WHO) B05XA11 (WHO)
Hazards
Main hazards	Irritant
Safety data sheet	ICSC 0764
R-phrases (outdated)	R36, R37, R38
S-phrases (outdated)	S26, S37, S39
NFPA 704 (fire diamond)	0 1 0
Flash point	Non-flammable
	Lethal dose or concentration (LD, LC):
LD50 (median dose)	2800 mg/kg (oral, rat)
Related compounds
Other anions	Magnesium fluoride; Magnesium bromide; Magnesium iodide
Other cations	Beryllium chloride; Calcium chloride; Strontium chloride; Barium chloride; Radium chloride
	Except where otherwise noted, data are given for materials in their standard state (at 25 °C [77 °F], 100 kPa).
	verify (what is ?)
	Infobox references

Magnesium chloride is the name for the chemical compound with the formula MgCl₂ and its various hydrates MgCl₂(H₂O)_x. Anhydrous MgCl₂ contains 25.5% elemental magnesium by mass. These salts are typical ionic halides, being highly soluble in water. The hydrated magnesium chloride can be extracted from brine or sea water. In North America, magnesium chloride is produced primarily from Great Salt Lake brine. It is extracted in a similar process from the Dead Sea in the Jordan Valley. Magnesium chloride, as the natural mineral bischofite, is also extracted (by solution mining) out of ancient seabeds, for example, the Zechstein seabed in northwest Europe. Some magnesium chloride is made from solar evaporation of seawater. Anhydrous magnesium chloride is the principal precursor to magnesium metal, which is produced on a large scale. Hydrated magnesium chloride is the form most readily available.

Structure, preparation, and general properties

MgCl₂ crystallizes in the cadmium chloride motif, which features octahedral Mg centers. Several hydrates are known with the formula MgCl₂(H₂O)_x, and each loses water at higher temperatures: x = 12 (−16.4 °C), 8 (−3.4 °C), 6 (116.7 °C), 4 (181 °C), 2 (about 300 °C).[1] In the hexahydrate, the Mg²⁺ is also octahedral, but is coordinated to six water ligands.[2] The thermal dehydration of the hydrates MgCl₂(H₂O)_x (x = 6, 12) does not occur straightforwardly.[3] Anhydrous MgCl₂ is produced industrially by heating the chloride salt of hexammine complex [Mg(NH₃)₆]²⁺.[4]

As suggested by the existence of some hydrates, anhydrous MgCl₂ is a Lewis acid, although a weak one.

In the Dow process, magnesium chloride is regenerated from magnesium hydroxide using hydrochloric acid:

Mg(OH)₂(s) + 2 HCl(aq) → MgCl₂(aq) + 2 H₂O(l)

It can also be prepared from magnesium carbonate by a similar reaction.

Derivatives with tetrahedral Mg²⁺ are less common. Examples include salts of (tetraethylammonium)₂MgCl₄ and adducts such as MgCl₂(TMEDA).[5]

Applications

Precursor to Mg metal

MgCl₂ is the main precursor to metallic magnesium. The conversion is effected by electrolysis:[4][6]

MgCl₂ → Mg + Cl₂

This process is practiced on a substantial scale.

Dust and erosion control

Magnesium chloride is one of many substances used for dust control, soil stabilization, and wind erosion mitigation.[7] When magnesium chloride is applied to roads and bare soil areas, both positive and negative performance issues occur which are related to many application factors.[8]

Catalyst support

Ziegler-Natta catalysts, used commercially to produce polyolefins, contain MgCl₂ as a catalyst support.[9] The introduction of MgCl₂ supports increases the activity of traditional catalysts and allowed the development of highly stereospecific catalysts for the production of polypropylene.[10]

Ice control

Picture of truck applying liquid de-icer (magnesium chloride) to city streets

Picture of solid form of rock salt used for ice removal on streets

Magnesium chloride is used for low-temperature de-icing of highways, sidewalks, and parking lots. When highways are treacherous due to icy conditions, magnesium chloride helps to prevent the ice bond, allowing snow plows to clear the roads more efficiently.

Magnesium chloride is used in three ways for pavement ice control: Anti-icing, when maintenance professionals spread it onto roads before a snow storm to prevent snow from sticking and ice from forming; prewetting, which means a liquid formulation of magnesium chloride is sprayed directly onto salt as it is being spread onto roadway pavement, wetting the salt so that it sticks to the road; and pretreating, when magnesium chloride and salt are mixed together before they are loaded onto trucks and spread onto paved roads. Calcium chloride damages concrete twice as fast as magnesium chloride.[11] It should be noticed that the amount of magnesium chloride is supposed to be controlled when it is used for de-icing as it may cause pollution to the environment.[12]

Nutrition and medicine

Magnesium chloride is used in nutraceutical and pharmaceutical preparations.

Cuisine

Magnesium chloride (E511[13]) is an important coagulant used in the preparation of tofu from soy milk. In Japan it is sold as nigari (にがり, derived from the Japanese word for "bitter"), a white powder produced from seawater after the sodium chloride has been removed, and the water evaporated. In China, it is called lushui (卤水). Nigari or lushui consists mostly of magnesium chloride, with some magnesium sulphate and other trace elements. It is also an ingredient in baby formula milk.[14]

Gardening and horticulture

Because magnesium is a mobile nutrient, magnesium chloride can be effectively used as a substitute for magnesium sulfate (Epsom salt) to help correct magnesium deficiency in plants via foliar feeding. The recommended dose of magnesium chloride is smaller than the recommended dose of magnesium sulfate (20 g/l).[15] This is due primarily to the chlorine present in magnesium chloride, which can easily reach toxic levels if over-applied or applied too often.[16]

It has been found that higher concentrations of magnesium in tomato and some pepper plants can make them more susceptible to disease caused by infection of the bacterium Xanthomonas campestris, since magnesium is essential for bacterial growth.[17]

Occurrence

Chemical composition of sea salt

Magnesium values in natural seawater are between 1250 and 1350 mg/l, around 3.7% of the total seawater mineral content. Dead Sea minerals contain a significantly higher magnesium chloride ratio, 50.8%. Carbonates and calcium are essential for all growth of corals, coralline algae, clams, and invertebrates. Magnesium can be depleted by mangrove plants and the use of excessive limewater or by going beyond natural calcium, alkalinity, and pH values.[18]

Toxicology

Magnesium ions are bitter-tasting, and magnesium chloride solutions are bitter in varying degrees, depending on the concentration of magnesium.

Magnesium toxicity from magnesium salts is rare in healthy individuals with a normal diet, because excess magnesium is readily excreted in urine by the kidneys. A few cases of oral magnesium toxicity have been described in persons with normal renal function ingesting large amounts of magnesium salts, but it is rare. If a large amount of magnesium chloride is eaten, it will have effects similar to magnesium sulfate, causing diarrhea, although the sulfate also contributes to the laxative effect in magnesium sulfate, so the effect from the chloride is not as severe.

Plant toxicity

Chloride (Cl⁻) and magnesium (Mg²⁺) are both essential nutrients important for normal plant growth. Too much of either nutrient may harm a plant, although foliar chloride concentrations are more strongly related with foliar damage than magnesium. High concentrations of MgCl₂ ions in the soil may be toxic or change water relationships such that the plant cannot easily accumulate water and nutrients. Once inside the plant, chloride moves through the water-conducting system and accumulates at the margins of leaves or needles, where dieback occurs first. Leaves are weakened or killed, which can lead to the death of the tree.[19]

Locomotive boiler problem

The presence of dissolved magnesium chloride in the well water (bore water) used in locomotive boilers on the Trans-Australian Railway caused serious and expensive maintenance problems during the steam era. At no point along its route does the line cross a permanent freshwater watercourse, so bore water had to be relied on. No inexpensive treatment for the highly mineralised water was available, and locomotive boilers were lasting less than a quarter of the time normally expected.[20] In the days of steam locomotion, about half the total train load was water for the engine. The line's operator, Commonwealth Railways, was an early adopter of the diesel-electric locomotive.

gollark: I switched out the colors again. This might work as a colourblindness test.

gollark: (the second last one is randomized)

gollark: The colors in all but the second-last remain unfinalized.

gollark: Fiiiiiine, next time I might work out a way to somehow combine them into one image.

gollark: Here are some new logo concepts for osmarks.net.

Notes and references

Notes

Holleman, A. F.; Wiberg, E. Inorganic Chemistry Academic Press: San Diego, 2001. ISBN 0-12-352651-5.
Wells, A. F. (1984) Structural Inorganic Chemistry, Oxford: Clarendon Press. ISBN 0-19-855370-6.
See notes in Rieke, R. D.; Bales, S. E.; Hudnall, P. M.; Burns, T. P.; Poindexter, G. S. "Highly Reactive Magnesium for the Preparation of Grignard Reagents: 1-Norbornane Acid", Organic Syntheses, Collected Volume 6, p. 845 (1988). "Archived copy" (PDF). Archived from the original (PDF) on 2007-09-30. Retrieved 2007-05-10.CS1 maint: archived copy as title (link)
Margarete Seeger; Walter Otto; Wilhelm Flick; Friedrich Bickelhaupt; Otto S. Akkerman. "Magnesium Compounds". Ullmann's Encyclopedia of Industrial Chemistry. Weinheim: Wiley-VCH. doi:10.1002/14356007.a15_595.pub2.
N. N. Greenwood, A. Earnshaw, Chemistry of the Elements, Pergamon Press, 1984.
Hill, Petrucci, McCreary, Perry, General Chemistry, 4th ed., Pearson/Prentice Hall, Upper Saddle River, New Jersey, USA.
"Dust Palliative Selection and Application Guide". Fs.fed.us. Retrieved 2017-10-18.
https://www.nrcs.usda.gov/Internet/FSE_DOCUMENTS/stelprdb1043546.pdf
Dennis B. Malpass (2010). "Commercially Available Metal Alkyls and Their Use in Polyolefin Catalysts". In Ray Hoff; Robert T. Mathers (eds.). Handbook of Transition Metal Polymerization Catalysts. John Wiley & Sons, Inc. pp. 1–28. doi:10.1002/9780470504437.ch1. ISBN 9780470504437.
Norio Kashiwa (2004). "The Discovery and Progress of MgCl₂-Supported TiCl₄ Catalysts". Journal of Polymer Science A. 42 (1): 1–8. Bibcode:2004JPoSA..42....1K. doi:10.1002/pola.10962.
Jain, J., Olek, J., Janusz, A., and Jozwiak-Niedzwiedzka, D., "Effects of Deicing Salt Solutions on Physical Properties of Pavement Concretes", Transportation Research Record: Journal of the Transportation Research Board, No. 2290, Transportation Research Board of the National Academies, Washington, D.C., 2012, pp. 69-75. doi:10.3141/2290-09.
Dai, H.L.; Zhang, K.L.; Xu, X.L.; Yu, H.Y. (2012). "Evaluation on the Effects of Deicing Chemicals on Soil and Water Environment". Procedia Environmental Sciences. 13: 2122–2130. doi:10.1016/j.proenv.2012.01.201.
Food Standard Agency. "Current EU approved additives and their E Numbers". Retrieved 22 March 2010.
"Listed under ingredients for Similac Hypoallergenic Infant Formula with Iron (Abbott Nutrition)". abbottnutrition.com. Retrieved 2013-07-22.
"Comparison of Magnesium Sulfate and THIS Mg Chelate Foliar Sprays". Canadian Journal of Plant Science. 1970-01-01. doi:10.4141/cjps85-018.
"Magnesium Chloride Toxicity in Trees". Ext.colostate.edu. Retrieved 2017-10-18.
"Effect of Foliar and Soil Magnesium Application on Bacterial Leaf Spot of Peppers" (PDF). Retrieved 2017-10-18.
"Aquarium Chemistry: Magnesium In Reef Aquaria — Advanced Aquarist | Aquarist Magazine and Blog". Advancedaquarist.com. 2003-10-15. Retrieved 2013-01-17.
"Publications – ExtensionExtension". Ext.colostate.edu. Archived from the original on 2015-09-24. Retrieved 2017-10-18.
"Overland Locomotive:Feed Water Problems". The Argus. 1927-03-21. Retrieved 2014-03-11.

References

Handbook of Chemistry and Physics, 71st edition, CRC Press, Ann Arbor, Michigan, 1990.

External links

This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.

[1] Holleman, A. F.; Wiberg, E. Inorganic Chemistry Academic Press: San Diego, 2001. ISBN 0-12-352651-5.

[2] Wells, A. F. (1984) Structural Inorganic Chemistry, Oxford: Clarendon Press. ISBN 0-19-855370-6.

[3] See notes in Rieke, R. D.; Bales, S. E.; Hudnall, P. M.; Burns, T. P.; Poindexter, G. S. "Highly Reactive Magnesium for the Preparation of Grignard Reagents: 1-Norbornane Acid", Organic Syntheses, Collected Volume 6, p. 845 (1988). "Archived copy" (PDF). Archived from the original (PDF) on 2007-09-30. Retrieved 2007-05-10.CS1 maint: archived copy as title (link)

[ullmann-4] Margarete Seeger; Walter Otto; Wilhelm Flick; Friedrich Bickelhaupt; Otto S. Akkerman. "Magnesium Compounds". Ullmann's Encyclopedia of Industrial Chemistry. Weinheim: Wiley-VCH. doi:10.1002/14356007.a15_595.pub2.

[5] N. N. Greenwood, A. Earnshaw, Chemistry of the Elements, Pergamon Press, 1984.

[Hill-6] Hill, Petrucci, McCreary, Perry, General Chemistry, 4th ed., Pearson/Prentice Hall, Upper Saddle River, New Jersey, USA.

[fs.fed.us-7] "Dust Palliative Selection and Application Guide". Fs.fed.us. Retrieved 2017-10-18.

[nrcs.usda.gov-8] ttps://www.nrcs.usda.gov/Internet/FSE_DOCUMENTS/stelprdb1043546.pdf

[9] Dennis B. Malpass (2010). "Commercially Available Metal Alkyls and Their Use in Polyolefin Catalysts". In Ray Hoff; Robert T. Mathers (eds.). Handbook of Transition Metal Polymerization Catalysts. John Wiley & Sons, Inc. pp. 1–28. doi:10.1002/9780470504437.ch1. ISBN 9780470504437.

[10] Norio Kashiwa (2004). "The Discovery and Progress of MgCl₂-Supported TiCl₄ Catalysts". Journal of Polymer Science A. 42 (1): 1–8. Bibcode:2004JPoSA..42....1K. doi:10.1002/pola.10962.

[11] Jain, J., Olek, J., Janusz, A., and Jozwiak-Niedzwiedzka, D., "Effects of Deicing Salt Solutions on Physical Properties of Pavement Concretes", Transportation Research Record: Journal of the Transportation Research Board, No. 2290, Transportation Research Board of the National Academies, Washington, D.C., 2012, pp. 69-75. doi:10.3141/2290-09.

[12] Dai, H.L.; Zhang, K.L.; Xu, X.L.; Yu, H.Y. (2012). "Evaluation on the Effects of Deicing Chemicals on Soil and Water Environment". Procedia Environmental Sciences. 13: 2122–2130. doi:10.1016/j.proenv.2012.01.201.

[ceua-13] Food Standard Agency. "Current EU approved additives and their E Numbers". Retrieved 22 March 2010.

[14] "Listed under ingredients for Similac Hypoallergenic Infant Formula with Iron (Abbott Nutrition)". abbottnutrition.com. Retrieved 2013-07-22.

[15] "Comparison of Magnesium Sulfate and THIS Mg Chelate Foliar Sprays". Canadian Journal of Plant Science. 1970-01-01. doi:10.4141/cjps85-018.

[16] "Magnesium Chloride Toxicity in Trees". Ext.colostate.edu. Retrieved 2017-10-18.

[17] "Effect of Foliar and Soil Magnesium Application on Bacterial Leaf Spot of Peppers" (PDF). Retrieved 2017-10-18.

[18] "Aquarium Chemistry: Magnesium In Reef Aquaria — Advanced Aquarist | Aquarist Magazine and Blog". Advancedaquarist.com. 2003-10-15. Retrieved 2013-01-17.

[colostate1-19] "Publications – ExtensionExtension". Ext.colostate.edu. Archived from the original on 2015-09-24. Retrieved 2017-10-18.

[20] "Overland Locomotive:Feed Water Problems". The Argus. 1927-03-21. Retrieved 2014-03-11.