Fokker F28 Fellowship

The Fokker F28 Fellowship is a twin-engine short range jet airliner designed and built by Dutch aircraft manufacturer Fokker.

F28 Fellowship
A Piedmont F28-1000 on approach
Role Regional jet
National origin Netherlands
Manufacturer Fokker
First flight 9 May 1967
Introduction 28 March 1969 with Braathens SAFE
Status In military service[1][2]
Primary user Garuda Indonesia (historical)
AirQuarius Aviation (historical)
Linjeflyg (historical)
Biman Bangladesh Airlines (historical)
Produced 1967–1987
Number built 241
Unit cost
Mk 1000: US$2.9M, Mk 2000: US$3M (1970)[3] US$19-20M today
Variants Fairchild 228
Developed into Fokker 70
Fokker 100

Following the Fokker F27 Friendship, an early and commercially successful turboprop-powered regional airliner, Fokker decided to embark on developing a new turbojet-powered commuter aircraft that would build upon its experiences with the F27. During the design phase, a high level of attention was paid to market research and operator concerns; amongst other changes made, the prospective jetliner was increased in size, changing its maximum seating capacity from 50 to 65 passengers. During April 1962, Fokker announced the formal launch of the F28 Fellowship.

On 9 May 1967, the prototype F28-1000 conducted its maiden flight. Type certification was achieved on 24 February 1969, and the first revenue-earning flight by Braathens was performed on 28 March 1969. Following its entry to service, Fokker developed multiple variants of the F28; one model, the F28-2000, featured an extended fuselage that could accommodate up to 79 passengers. A major revision was the F28-4000, which was powered by quieter Rolls-Royce Spey 555-15H engines, a redesigned cockpit, a modified wing, and had a further increased seating capacity of up to 85 passengers. During 1987, production of the type was terminated in favour of two newer derivatives, the Fokker 70 and the larger Fokker 100.

Development
Prototype one month before its 9 May 1967 first flight

By 1960, Dutch aircraft manufacturer Fokker was engaged in multiple programmes; these included military aircraft such as the Bréguet Br.1150 Atlantic and the Lockheed F-104 Starfighter, as well as the commercially successful turboprop-powered F27 Friendship airliner.[4] Around this time, British European Airways (BEA) released a specification that called for a high speed regional airliner powered by turbojet engines.[5] In response, Fokker took an interest in developing its own turbojet-powered short-haul airliner.[6] According to aviation publication Flying, Fokker's prospective jetliner design was heavily shaped by feedback and experiences from its existing customers of the F27, particularly those in the crucial North American market. As such, American design methodologies and preferences were incorporated, reportedly emphasising simplicity, as well as efforts to minimise both language and trade barriers.[7]

During April 1962, Dutch aircraft manufacturer Fokker announced the launch of the F28 Fellowship. The programme was a collaborative effort conducted between a number of European companies, namely Fokker itself, West German aerospace companies Messerschmitt-Bölkow-Blohm (MBB) and VFW-Fokker, as well as Short Brothers of Northern Ireland. Substantial government funding was also invested in the project; reportedly, the Dutch government provided 50% of Fokker's stake while the West German government contributed 60% of the overall 35% German stake. Fokker had also approached several other aviation companies with offers of involvement, including France's Sud Aviation and Britain's Hawker Siddeley.[4]

Initial design work centered on an aircraft capable of transport a maximum of 50 passengers across distances of up to 1,650 km (1,025 mi), the design was later modified so that it could accommodate up to 65 seats in a five-abreast configuration, noticeably increasing its maximum takeoff weight (MTOW), on the basis of market research.[8] The enlarged aircraft was roughly comparable in capacity to that of the British Vickers Viscount, a successful turboprop airliner.[9] The design was capable of speeds well in excess of turboprop-powered competitors, but retained a relatively low cruise speed in comparison to contemporary jet-powered designs, facilitating its use of a relatively straight low-mounted wing and achieving favourable low-speed characteristics as to enable the type's use from 85% of existing airports used by the F27 and the ubiquitous Douglas DC-3. According to Flying, the tentative airliner could achieve double the productivity of the preceding F27, while the company itself referred to the jetliner as a complement to its turboprop-powered sibling.[9]

At one stage of development, Fokker had reportedly intended for the F28 to be powered by a pair of Bristol Siddeley BS.75 turbofans. However, this selection was hotly contested by rival British engine manufacturer Rolls-Royce, who put forward their Rolls-Royce Spey Junior, a simplified version of the Rolls-Royce Spey. Rolls-Royce ultimately emerged victorious, from the first prototype onwards, the type would be exclusively powered by various models of the Spey engine.[10]

The responsibility for both design and production of the F28 was divided between the partner companies. Fokker designed and built the nose section, centre fuselage and inner wing; MBB/Fokker-VFW constructed the forward fuselage, rear fuselage and tail assembly; while Shorts designed and produced the outer wings.[5] Final assembly of the Fokker F28 was at Schiphol Airport in the Netherlands. At one point, American manufacturer Fairchild Aircraft had considered locally-producing their own derivative of the F28, which was referred to as the Fairchild 228, but this ultimately did not reach production, deciding to act as a distributor for the existing F28 instead.[5] During 1987, production of the type was terminated in favour of two newer derivative airliners, the Fokker 70 and the larger Fokker 100; by this point, a total of 241 airframes had been constructed.[11][12]

The F28-1000 prototype, registered PH-JHG, first flew on 9 May 1967, flown by Chief Test Pilot Jas Moll, Test Pilot Abe van der Schraaf and Flight Engineer Cees Dik. Type certification from West German authorities was achieved on 24 February 1969, clearing the F28 to enter revenue service. While the first order for the type had been placed by German airline LTU, the first revenue-earning flight was conducted by Braathens, who eventually operated a fleet of five F28s, on 28 March 1969.[11]

Design
Five-abreast seating

The Fokker F28 Fellowship was a short-haul twin-engine jetliner, sharing broad similarities to the British Aircraft Corporation's BAC One-Eleven built in the UK and the first generation Douglas DC-9 built in the US in terms of basic configuration, featuring a T-tail and engines mounted at the rear of the fuselage.[5] The choice of a low-mounted wing, amongst other benefits, somewhat shielded the tail-mounted engines from the threat of foreign object damage. Fuel is stored within both the outer wing and within the fuselage; additional pylon-mounted tanks could be installed for extended range operations if so required.[13] The structure, which features a fail-safe design, is constructed using the same bonding techniques previously pioneered for the F27.[10]

The F28 was equipped with wings that had a slight crescent angle of sweep. It uses conventional box construction, being built in two pieces separately spliced onto the fuselage.[9] The wing was furnished with ailerons positioned near the tips, along with simplistic flaps that would be supplemented by the ailerons during landing approaches; all of the flight control surfaces were actuated via duplicated cabling and (except for the rudder) aerodynamically balanced.[4] It was also fitted with a five-section lift-dumper that would only be operated after landing, it was decided to employ a lift-dumper rather than alternatives such as thrust reversers as the designers felt that this arrangement would result in a reduction in both weight and maintenance workload. Excluding the use of thrust reversers also meant that there was less chance of the engines ingesting debris when being operated upon unpaved airstrips. The wing also had a fixed leading edge (although one experimental model had leading edge slats and these were offered as an option) and was de-iced via bleed air drawn from the engines.[10]

The F28 is powered by a pair of Rolls-Royce Spey turbojet engines; dependent on model, these would be were capable of generating up to 9,850lbf / 43.9kN of thrust.[14] While the feature was available at the time, Fokker chose not to equip the engines of early F28s with a water-methanol injection system as they determined that the engines already possessed sufficient performance even when being flown under hot-and-high conditions.[8] The majority of onboard systems are designed with simplicity in terms of operability and serviceability; there was no hydraulic system, actuation of the undercarriage and steering relied on pneumatic pumps instead.[10] However, the F28 was outfitted with comparatively advanced electronics, as Fokker's design team viewed this factor as directly relating to overall competitiveness.[4]

One uncommon feature of the F28 was the movable split-sections installed upon the tail cone; these would be hydraulically-opened outwards to act as a variable air brake. A similar approach had also been used on the contemporaneous Blackburn Buccaneer strike fighter and on the later-built British Aerospace 146 regional airliner. The design is unique in that it not only slows the aircraft down rapidly, it can aid in rapid descents from economic cruising altitudes and also allowed the engines to be set at higher RPM which helped eliminate 'lag time'. This means the engines respond faster if needed for sudden speed increases or go-arounds on the approach to landing. The Fellowship had a retractable tricycle landing gear which used large low pressure tyres, enabling the use of unpaved airstrips. The use of anti-skid brakes on the main wheels of the undercarriage also contributed to a shorter landing run.[4]

Variants
The Mk 2000 has a 87 in (2.2 m) longer fuselage
The Mk 4000 has the Mk 2000 longer fuselage with double overwing exits and a 60 in (1.5 m) wider wing
The Mk 3000 has the Mk 4000 wider wing and the Mk 1000 shorter fuselage

A variant of the F28, equipped with an extended fuselage, was named F28-2000; this model could seat up to 79 passengers instead of the 65 seats on the F28-1000. The prototype for this model was a converted F28-1000 prototype, and first flew on 28 April 1971. The models F28-6000 and F28-5000 were modified F28-2000 and F28-1000 respectively; the main features of these models was the addition of slats, a greater wingspan, and the adoption of more powerful and quieter engines. Both the F28-6000 and F28-5000 failed to become commercial successes; only two F28-6000 and no F28-5000 were ultimately built. After being used by Fokker for a time, the F28-6000 were sold to Air Mauritanie, but not before being converted to F28-2000 standard.[11]

Perhaps the most successful model of the F28 was the F28-4000, which debuted on 20 October 1976 with one of the world's largest Fokker operators, Linjeflyg. This version was powered by quieter Spey 555-15H engines, and had an increased seating capacity (up to 85 passengers), a larger wingspan with reinforced wings, a new cockpit and a new "wide-look" interior featuring enclosed overhead lockers and a less 'tubular' look. The F28-3000, the successor to the F28-1000, featured the same improvements as the F28-4000.

F.28 Mk 1000 (F28-1000)
With a maximum capacity of 70 passengers, it was approved on 24 February 1969, the 1000C had a Main Deck Large Cargo Door.[15]
F.28 Mk 2000 (F28-2000)
Mark 1000 with a fuselage stretch of 57 in (1.4 m) in front of and 30 in (0.76 m) aft of the wing, 79 maximum passengers, approved on 30 August 1972.[15] Though it first flew on 28 April 1971 and successfully began revenue service with Nigeria Airways in October 1971, only ten were built.[11]
F.28 Mk 3000 (F28-3000)
Mark 1000 with a 60 in (1.5 m) wing span extension, approved on 19 July 1978, with a 3000C variant with a large main deck cargo door.[15] A successful variant, featuring greater structural strength and increased fuel capacity, it began revenue service with Garuda Indonesia.[11]
F.28 Mk 4000 (F28-4000)
Approved on 13 December 1976, it is built on the longer Mark 2000, with two overwing exits on both sides, a 60 in (1,500 mm) wing span extension, and capacity for 85 passengers.[15] The first prototype appeared on 20 October 1976 and it began service with Linjeflyg (Sweden) at the end of the year.[11]
F.28 Mk 5000 (F28-5000)
Was to combine the shorter fuselage of the Mk 3000 and an increased wingspan. Leading edge slats were to be added to the wings and more powerful Rolls-Royce RB183 Mk555-15H engines were to be used. Although expected to be an excellent plane to operate on short runways due to its superior power, the project was abandoned.[11]
F.28 Mk 6000 (F28-6000)
It first flew on 27 September 1973 and had the longer fuselage of the Mk 2000/4000 with an increased wingspan and leading edge slats. It was certified in the Netherlands on 30 October 1975. Two were built by 1976.[11][16]
F.28 Mk 6600 (F28-6600)
Proposed version. Not built.[11]
Fairchild 228
Proposed 50 seat American version to be assembled by Fairchild-Hiller with Rolls-Royce RB.203 Trent engines.[17] Project cancelled.

Operators
Main article: List of Fokker F28 operators

In August 2006 a total of 92 Fokker F28 aircraft remained in airline service. Major operators included: MacRobertson Miller Airlines, Ansett Group Australia (more than 15), Toumaï Air Tchad (1), AirQuarius Aviation (3), SkyLink Arabia (1), Satena (1), Gatari Air Service (2), LADE (1), AirQuarius Aviation (4) and Merpati Nusantara Airlines (1). Biman Bangladesh Airlines (4). Some 22 airlines operated smaller numbers of the type.[18] As of July 2018, Fly-SAX is the only airline operator of the F28 worldwide with 1 aircraft in service.[19] Garuda Indonesia had the most F28s, with 62 of the aircraft in the former fleet. All have since been retired.

The F28s of Ansett Transport Industries' Western Australian intrastate airline, MacRobertson Miller Airlines of Western Australia, flew the longest non-stop F28 route in the world, from Perth to Kununurra, in Western Australia – a distance of about 2,240 km (1,392 mi). This was also the world's longest twin-jet route at the time. MMA's F28's also had the highest utilisation rates at the time, flying over 8 hours per day.

Military operators
Argentine Naval Aviation F-28
 Algeria
 Argentina
 Colombia
 Ghana
 Indonesia
 Malaysia
  • Malaysian Air Force (2)
 Peru
 Philippines
 Tanzania
 Togo (2)

Accidents and incidents
Wreckage of Braathens SAFE Flight 239

The following is a list of Fokker F28 accidents and incidents:

  • Braathens SAFE Flight 239 – 23 December 1972, (Asker, suburb of Oslo, Norway): 40 fatalities. First fatal crash of a Fokker Fellowship.
  • Itavia – 1 January 1974, (Caselle Torinese, airport of Turin, Italy): 38 fatalities. Flight IH897 from Cagliari to Geneva with intermediate stops in Bologna and Turin, crashed about 2 miles south of Runway 36 while attempting to land in fog. Airplane involved was registered I-TIDE.
  • Turkish Airlines – 26 January 1974, (Izmir, Turkey): 66 fatalities. The aircraft crashed down 100 m (330 ft) away from the airfield during takeoff.
  • Garuda Indonesia Airways Flight 150- 24 September 1975 near Palembang, Indonesia: 26 fatalities. Crashed on approach in fog killing 25 people out of 61 passengers and crew. 1 person was killed on the ground.
  • Garuda Indonesia Airways- 11 July 1979. 61 fatalities. Crashed into Mount Sibayak while on approach to Polonia International Airport. There was bad weather at the time of the crash.
  • NLM CityHopper Flight 431 – 6 October 1981 (Moerdijk, North Brabant, Netherlands): 17 fatalities, the aircraft flew into a tornado which broke off one of the wings.
  • Garuda Indonesia Domestic Flight – 20 March 1982, runway overrun at Tanjung Karang-Branti Airport in bad weather, 27 fatalities.
  • Air Ontario Flight 1363 – 10 March 1989 (Dryden, Ontario, Canada): 24 fatalities. Due to various factors including snow, ice and lack of use of anti-icing measures.
  • USAir Flight 405 – 22 March 1992 (Queens, New York, United States): 27 fatalities. Due to ice buildup on the wings, pilot error and improper deicing procedures at LaGuardia airport
  • Merpati Nusantara Airlines Flight 724 – Fokker F-28 Mk-3000 Registered PK-GFU - 1 June 1993. Domestic Flight (Sorong, Papua, Indonesia): 41 fatalities. Controlled flight Into terrain - The aircraft crashed onto a rocky beach on Bad Weather Landing procedures at Jefman Airport[22]
  • Iran Aseman Airlines Flight 746 – 12 October 1994 (near Natanz, Iran): 66 fatalities.
  • Air Mauritanie Flight 625 – 1 July 1994: All 4 crew and 76 of the 89 passengers on board were killed when their plane crashed at Tidjikja Airport.
  • TANS Peru Flight 222 – 9 January 2003: None of the 46 passengers aboard the Fokker F-28 survived after the aircraft hit a mountain near Chachapoyas, Peru.

Aircraft on display

Specifications
Variant -1000[14]-2000[14] -4000[28]-3000[28]
Seating[lower-alpha 1] 65798565
Hold 459 cu.ft / 13m³559 cu.ft / 15.9m³459 cu.ft / 13 m³
Length 89ft 10in /27.4m97ft 2in / 29.6m89ft 10.7in / 27.4m
Height 27ft 9.5in / 8.47m
Wingspan 77ft 4in / 23.6m82ft 3in / 25.07m
Wing 822ft² / 76.4m², 16° sweep, 7.3:1 AR 850ft² / 79m², 16° sweep, 8:1 AR
Max takeoff weight 65,000lb / 29,480 kg 73,000lb / 33,110 kg
Empty weight 35,517lb / 16,144kg36,953 / 16,707kg38,825lb / 17,611 kg37,139lb / 16,846kg
Max payload 18,983 / 8,629kg17,547 / 7,976kg23,317lb / 10,556kg19,003lb / 8,620kg
Max Fuel 2,869 Imp Gal / 13,040 l
2× Turbofans Rolls-Royce Spey Mk 555-15 Rolls-Royce Spey Mk 555-15H
Unit thrust 9,850lbf / 43.9kN
Cruise 458kn / 848km/h Max, 359kn / 666 km/h LR 436kn / 808km/h Max, 354kn / 656 km/h LR
Fuel Consumption 6,180lb/h / 2,800kg/h Max, 3,260lb/h / 1,480kg/h LR 4,980lb/h / 2,260kg/h Max, 3,252lb/h / 1,475kg/h LR
Max PL Range 920nmi / 1,705km900nmi / 1,668km1,550nmi / 2,872 km
Takeoff (MTOW, ISA, SL) 5,500ft / 1,676m
Landing (MLW, SL) 3,540ft / 1,079m3,495ft /1,065m3,173ft / 967m
Service ceiling 35,000 ft (10,700 m)[15]
  1. 5-abreast, 31in / 79cm pitch
gollark: Some offense <@!160279332454006795>.
gollark: It does not. It was written several months ago and is really quite bad.
gollark: For some reason CraftOS-PC just says it can't mount the ROM whenever I try to use it, even though my ROM folder exists and is readable and I tried directly passing it the path to it.
gollark: I had to add some horrible hacks to the VFS redirection logic to mmake it work at all.
gollark: Excitingly, the new potatOS thing actually incorporates a lisp interpreter for some reason I forgot.

See also

Related development

Aircraft of comparable role, configuration and era

Related lists

References

Citations
  1. rzjets.net
  2. planelogger.com
  3. "Fokker F.28 Series 2000". Flight International. 21 May 1970.
  4. May 1963, p. 94.
  5. Eden 2016, p. 124.
  6. May 1963, p. 25.
  7. May 1963, pp. 25, 92.
  8. May 1963, pp. 93-94.
  9. May 1963, p. 92.
  10. May 1963, p. 93.
  11. Antonio López Ortega (1999). Reactores Comerciales [Commercial Jetliners] (in Spanish). Agualarga Editores S.l. ISBN 978-84-95088-87-1.
  12. Eden 2016, pp. 126-127.
  13. May 1963, pp. 92-93.
  14. "Commercial aircraft survey". Flight International. 24 October 1974.
  15. "Type Certificate Data Sheet No. A.037 for Fokker F28" (PDF). EASA. 3 September 2018.
  16. Taylor 1976, p. 137
  17. "What happened to the Fairchild 228?". AAHS Journal. Spring 1998.
  18. Flight International, 3–9 October 2006
  19. "World Airline Census 2018". Flightglobal.com. Retrieved 2018-08-26.
  20. "Trade Registers".
  21. Air International May 1988, p. 233.
  22. Ranter, Harro. "ASN Aircraft accident Fokker F-28 Fellowship 3000 PK-GFU Sorong-Jefman Airport (SOQ)".
  23. "Fokker F 28 1000 Fellowship". Norwegian Aviation Museum. Archived from the original on 10 July 2018. Retrieved 9 July 2018.
  24. "11 Unusual Preserved Airliners in the USA". Airport Spotting. 2017-07-03. Retrieved 9 July 2018.
  25. "Fokker News". Stichting AIRnieuws Nederland. Retrieved 26 March 2019.
  26. "Fokker F-28-4000, XY-AGH / 1114". ABPic. Retrieved 9 July 2018.
  27. "REGISTRATION DETAILS FOR PK-MGJ". Planelogger. Retrieved 9 July 2018.
  28. "Commuter airliner guide". Flight International. 21 March 1981.

Bibliography
  • "Andean Air Power...The Peruvian Air Force". Air International. Vol. 34 no. 5. May 1988. pp. 224–235, 240.
  • Eden, Paul E. "The World's Most Powerful Civilian Aircraft." Rosen Publishing Group, 2016. ISBN 1-4994-6588-2
  • May, Darryl. "Holland's Short-Haul Jet Transport." Flying Magazine, Vol. 72, No. 1. January 1963. pp. 25, 92-94. ISSN 0015-4806.
  • Taylor, John W. R., ed. (1976). Jane's All the World's Aircraft 1976–77. London: Jane's Yearbooks. ISBN 978-0-354-00538-8.CS1 maint: ref=harv (link)

Further reading
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.