Ixtoc I oil spill

Ixtoc I was an exploratory oil well being drilled by the semi-submersible drilling rig Sedco 135 in the Bay of Campeche of the Gulf of Mexico, about 100 km (62 mi) northwest of Ciudad del Carmen, Campeche in waters 50 m (164 ft) deep.[2] On 3 June 1979, the well suffered a blowout resulting in one of the largest oil spills in history.[3]

Ixtoc I
LocationBay of Campeche, Gulf of Mexico
Campeche, Mexico
Coordinates19.408333°N 92.325°W / 19.408333; -92.325
Date3 June 1979 – 23 March 1980
Cause
CauseWellhead blowout
OperatorPemex
Spill characteristics
Volume3 million barrels (130,000,000 U.S. gallons; 480,000 cubic meters)[1]
Area2,800 km2 (1,100 sq mi)
Shoreline impacted261 km (162 mi)

Accident

Mexico's state-owned oil company Pemex (Petróleos Mexicanos) was drilling a 3 km (1.9 mi) deep oil well when the drilling rig Sedco 135 lost drilling mud circulation.

In modern rotary drilling, mud is circulated down the drill pipe and back up the wellbore to the surface. The goal is to equalize the pressure through the shaft and to monitor the returning mud for gas. Without the counter-pressure provided by the circulating mud, the pressure in the formation allowed oil to fill the well column, blowing out the well. The oil caught fire, and Sedco 135 burned and collapsed into the sea.[2]

At the time of the accident Sedco 135 was drilling at a depth of about 3,600 metres (11,800 ft) below the seafloor.[4] The day before Ixtoc suffered the blowout and resulting fire that caused her to sink, the drill bit hit a region of soft strata. Subsequently, the circulation of drilling mud was lost resulting in a loss of hydrostatic pressure.[5] Rather than returning to the surface, the drilling mud was escaping into fractures that had formed in the rock at the bottom of the hole. Pemex officials decided to remove the bit, run the drill pipe back into the hole and pump materials down this open-ended drill pipe to seal off the fractures that were causing the loss of circulation.

During the removal of the pipe on Sedco 135, the drilling mud suddenly began to flow up towards the surface; by removing the drill-string the well was swabbed (an effect observed when mud must flow down the annulus to replace displaced drill pipe volume below the bit) leading to a kick. Normally, this flow can be stopped by activating shear rams contained in the blowout preventer (BOP). These rams are designed to sever and seal off the well on the ocean floor; however, in this case, the drill collars had been brought in line with the BOP and the BOP rams were not able to sever the thick steel walls of the drill collars leading to a catastrophic blowout.

The drilling mud was followed by a large quantity of oil and gas at a flow rate that was still increasing. The oil and gas fumes exploded on contact with the operating pump motors, starting a fire which led to the collapse of the Sedco 135 drilling tower. The collapse caused damage to underlying well structures. The damage to the well structures led to the release of significant quantities of oil into the Gulf.[4]

Volume and extent of spill
Spill c. September 1979

In the initial stages of the spill, an estimated 30,000 barrels (5,000 m3) of oil per day were flowing from the well. In July 1979, the pumping of mud into the well reduced the flow to 20,000 barrels (3,000 m3) per day, and early in August the pumping of nearly 100,000 steel, iron, and lead balls into the well reduced the flow to 10,000 barrels (2,000 m3) per day. Pemex claimed that half of the released oil burned when it reached the surface, a third of it evaporated, and the rest was contained or dispersed.[6] Mexican authorities also drilled two relief wells into the main well to lower the pressure of the blowout, however, the oil continued to flow for three months following the completion of the first relief well.[7] In total, around 138,600,000 US gallons of oil (gal)and 3.3 million barrels of oil were spilled throughout the, roughly, 10 months it took for the oil to stop leaking.[8]

Pemex contracted Conair Aviation to spray the chemical dispersant Corexit 9527 on the oil. A total of 493 aerial missions were flown, treating 1,100 square miles (2,800 km2) of oil slick. Dispersants were not used in the U.S. area of the spill because of the dispersant's inability to treat weathered oil. Eventually the on-scene coordinator (OSC) requested that Mexico stop using dispersants north of 25°N.[6]

In Texas, an emphasis was placed on coastal countermeasures protecting the bays and lagoons formed by the barrier islands. Impacts of oil on the barrier island beaches were ranked as second in importance to protecting inlets to the bays and lagoons. This was done with the placement of skimmers and booms. Efforts were concentrated on the Brazos-Santiago Pass, Port Mansfield Channel, Aransas Pass, and Cedar Bayou which during the spill was sealed with sand. Economically and environmentally sensitive barrier island beaches were cleaned daily. Laborers used rakes and shovels to clean beaches rather than heavier equipment which removed too much sand. Ultimately, 71,500 barrels (11,000 m3) of oil impacted 162 miles (260 km) of U.S. beaches, and over 10,000 cubic yards (8,000 m3) of oiled material were removed.[6]

Containment

In the next nine months, experts and divers including Red Adair were brought in to contain and cap the oil well.[6] An average of approximately 10,000 to 30,000 barrels (2,000 to 5,000 m3) per day were discharged into the Gulf until it was finally capped on 23 March 1980, nearly 10 months later.[9] In similarity to the Deepwater Horizon oil spill 31 years later, the list of methods attempted to remediate the leak included lowering a cap over the well, plugging the leak with mud and "junk", use of dispersants, and spending months attempting to drill relief wells.[10][11]

Aftermath

Prevailing currents carried the oil towards the Texas coastline. The US government had two months to prepare booms to protect major inlets. Pemex spent $100 million to clean up the spill and avoided most compensation claims by asserting sovereign immunity as a state-run company.[12]

The oil slick surrounded Rancho Nuevo, in the Mexican state of Tamaulipas, which is one of the few nesting sites for Kemp's ridley sea turtles. Thousands of baby sea turtles were airlifted to a clean portion of the Gulf of Mexico to help save the rare species.

Long-term effects

The oil that was lost during the blow-out polluted a considerable part of the offshore region in the Gulf of Mexico as well as much of the coastal zone, which consists primarily of sandy beaches and barrier islands often enclosing extensive shallow lagoons.

The oil on Mexican beaches in early September was calculated to be about 6000 metric tons. Based on reports from various groups and individuals, five times that figure is thought to represent a fair estimate of what had landed on Mexican beaches. Investigations along the Texas coast show that approximately 4000 metric tons of oil or less than 1 percent was deposited there. The rest of the oil, about 120,000 metric tons or 25 percent, sank to the bottom of the Gulf.[13]

The oil had a severe impact on the littoral crab and mollusk fauna of the beaches which were contaminated. The populations of crabs, e.g. the ghost crab Ocypode quadrata, was almost eliminated over a wide area. The crab populations on coral islands along the coast were also reduced to only a few percents of the normal populations about nine months after the spill.[13]

A study concluded that the most persistent problems were the coastal lagoons lining the bay, as well as the pollution of estuaries. Specifically, they had problematic effects on the breeding and growth of several different species of food fish species.[14]

The oil washed ashore, 30 cm (1 ft.) deep in some places, as it was pushed north by prevailing winds and currents until it crossed the Texas border two months later and eventually coated almost 170 miles (270 km) of US beaches. The beach that caused most international concern in Mexico was Rancho Nuevo, a key nesting ground for critically endangered Kemp's ridley sea turtles which had already moved inland in their hundreds to lay eggs. By the time the eggs hatched, the oil had reached the shore.

Fishing was banned or restricted by Mexican authorities in contaminated areas north and south of the well. Fish and octopus catches dropped by 50 to 70% from the 1978 levels.[13] Other species that had longer life spans took longer to recover, and it took until the late-1980s that the population of Kemp's ridley turtles, started recovering. Ridley turtles only produce a few hundred eggs each year, in contrast with the millions of eggs that shrimp lay.[15]

There is much less information on the impact of the Ixtoc I spill on benthic species (bottom dwellers). The best studies were on the Texas coast over 1000  km from the spill. Massive kills can occur when oil reaches the benthos in sufficient quantity. The only indication of a massive kill may be the remains of the dead organisms, but if they lack hard parts there will be little evidence.[16]

A report prepared for the US Bureau of Land Management concluded concerning the spill's effect on US waters:

Despite a massive intrusion of petroleum hydrocarbon pollutants from the Ixtoc I event into the study region of the South Texas Outer Continental Shelf during 1979-1980, no definitive damage can be associated with this or other known spillage events (e .g ., Burmah Agate ) on either the epibenthic commercial shrimp population (based on chemical evidence) or the benthic infaunal community. Such conclusions have no bearing on intertidal or littoral communities, which were not the subject of this study.[17]

gollark: Galacticraft allows this.
gollark: With slightly different acceleration, maybe.
gollark: But you can't *meaningfully* customize it, because all the rockets really do is go to orbit or not.
gollark: I'm not aware of whether it is or isn't not not not better than advanced AR rocketry.
gollark: Plus all the messing around with ID chips.

See also

References
  1. Marshall, Jessica (2010-06-01). "Gulf Oil Spill Not the Biggest Ever". Discovery News. Retrieved 2010-06-14.
  2. John Charles Milne (2 Nov 2008). "Sedco 135 Series". OilCity. Archived from the original on 20 December 2008. Retrieved 20 May 2010.
  3. Elena Egawhary (7 May 2010). "How big is the Deepwater Horizon oil spill?". BBC News. oil spilled ... first Iraq War, 1991. ... Although not a single offshore spill, it saw massive oil leaks that easily dwarf Ixtoc 1
  4. Linda Garmon (25 October 1980). "Autopsy of an Oil Spill". Science News. 118 (17). pp. 267–270.
  5. "Ixtoc 1 Oil Spill Economic Impact Study" (PDF). Bureau of Land Management. pp. 4–6. Retrieved 2010-05-06.
  6. Emergency Response Division Office of Response and Restoration, National Ocean Service. "Ixtoc I". IncidentNews. National Oceanic and Atmospheric Administration, US Department of Commerce. Archived from the original on 12 April 2012. Retrieved 30 May 2010.
  7. Robert Campbell (May 24, 2010). "BP's Gulf battle echoes monster '79 Mexico oil spill". Reuters.
  8. Julian Miglierini. "Mexicans still haunted by 1979 Ixtoc spill". BBC News. Retrieved April 1, 2020.
  9. Emergency Response Division Office of Response and Restoration, National Ocean Service. "Ixtoc I: Countermeasures / Mitigation". IncidentNews. National Oceanic and Atmospheric Administration, US Department of Commerce. Archived from the original on 10 May 2010. Retrieved 30 May 2010.
  10. "Catastrophic Thinking: How to Ensure Oil Spill Disasters Do Not Happen Again", Scientific American, July 27, 2010
  11. "The lost legacy of the last great oil spill", Scientific American, July 14, 2010
  12. "BP's Gulf battle echoes monster '79 Mexico oil spill". Reuters. 2010-05-24.
  13. Jernelöv, Arne; Lindén, Olof (1981). "The Caribbean: Ixtoc I: A Case Study of the World's Largest Oil Spill". Ambio. Allen Press for the Royal Swedish Academy of Sciences. 10 (6): 299–306. JSTOR 4312725.
  14. Berger, Matthew O.; Godoy, Emilio (2010-06-27). "Ixtoc Disaster Holds Clues to Evolution of an Oil Spill". Inter Press Service News Agency. Archived from the original on 2010-06-20.
  15. Glenn Garvin (2010-06-27). "After big 1979 spill, a stunning recovery". The News Observer. Archived from the original on 24 July 2010.
  16. Teal, John M.; Howarth, Robert W. (January 1984). "Oil spill studies: A review of ecological effects". Environmental Management. 8 (1): 27–43. Bibcode:1984EnMan...8...27T. doi:10.1007/BF01867871.
  17. ERCO/Energy Resources Co. Inc. (19 March 1982). "Ixtoc Oil Spill Assessment, Final Report, Executive Summary Prepared for the US Bureau of Land Management, Contract No. AA851-CTO-71" (.PDF). US Department of the Interior, Minerals Management Service Mission. p. 27. Retrieved 14 July 2010.
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.